Help, I'm freezing! What have others done to improve the heat output?

[aeroaddict]

As the title states. Third winter on the plane and I have tried to seal the windows, wing roots, etc......

On cold days I wear a ski glove on my throttle hand else the fingertips get numb.

Any suggestions? Second set of heat muffs?

[Dan L]

I used a D shaped weather strip along windows. Also check where the windshield meets the boot cowl. It’s easy to fine air leaks when it’s cold. Stopping the leaks makes all the difference.

D9220B0A-1B02-4E55-A570-574E160AAC77.jpg

this picture is from a year ago. The blue tape was stopping leaks.

[aeroaddict]

Thanks Dan.

Yea, I have sealed the windows, door, wing roots ...............

I was hoping someone had modified something to actually get more heat out of the heater. I mostly get warm air. I have checked the scat, muffs, etc. and all appear as they should.

[Andy]

I was hoping someone had modified something to actually get more heat out of the heater.

The FX-3 heater is very effective. I don't know if it is possible to retrofit any of the component to earlier aircraft.

My gripe is there is no way to bypass the heat exchangers and get unheated outside air through the heat ducts.

[aeroaddict]

Does the FX3 heat make it to the back seat? While I'm ok when dressed properly, the back seater is an ice cube.

[Andy]

Does the FX3 heat make it to the back seat? While I'm ok when dressed properly, the back seater is an ice cube.

Yes the FX-3 has a separate heat duct to the rear seat and this comes off the left heat exchanger. The right heat exchanger feeds the front seat floor duct.

The left muffler has several longitudinal ribs welded on to increase the hot surface area. The right muffler does not have these ribs.

Rear seat heat duct and outlets are integrated with the left center panel.

More info here - https://cubcrafters.com/c/2017/12/ca...eating-system/

[cityrancher]

I bought the electric 12 volt car seat pads and put them on both seats. Easy to use and great comfort.

Amazon.com: Seat Cushion with Heat:Winter Heated Seat Cover with Fast Heating On The Go to Reduce Stress : Health & Household

[aeroaddict]

Great idea. I may go with this until the cowl is off and I can develop enhancements (if possible).

Any headset static from the cushion? I installed a USB port and use (supposedly) shield cables and get static.

Cheers

[40m]

Great idea. I may go with this until the cowl is off and I can develop enhancements (if possible).

Any headset static from the cushion? I installed a USB port and use (supposedly) shield cables and get static.

Cheers

PM Sent

[cityrancher]

Great idea. I may go with this until the cowl is off and I can develop enhancements (if possible).

Any headset static from the cushion? I installed a USB port and use (supposedly) shield cables and get static.

Cheers

I never noticed any noise in the system.